The X-Bow allows for possible lower level forward placement of the ship’s control-bridge above and immediately behind the bow of future container ships. Such ships would carry containers to the rear of and stacked to higher elevation than the bridge, with telescopic air intakes that extend upward above the containers, located near the ship stern to supply air to the engine. The combination could offer greater operational versatility on select ship routes.
Container ships carry most of the world’s trade and despite the pandemic lockdowns being enforced in many countries and ongoing trade disputes with China, future trade moving aboard container ships is likely to increase. The closures of factories in China translates to factories producing consumer goods at competitive prices being opened in other nearby Asian nations, with major Asian container transshipment terminals processing greater numbers of containers within as little as a decade. In Egypt, the Suez Canal Commission has planned for a future where large container ships will sail along the canal.
Plans are underway to develop twin navigation channels at greater navigation depth to transit wider, deeper draft, slightly longer and slightly higher container ships built to 28,000 to 34,000-TEU capacity. Installing the ship control bridge above the bow allows for higher stacking of containers while installing telescopic air intakes at the stern area would allow for air to flow above the containers and into the air intakes. Upon approach to a bridge, the telescopic air intakes would briefly retract. The dynamics of the X-bow when sailing through waves enhances prospects for forward located control bridges on future container ships.
Ships sail below bridges on approach to many ports internationally. While some bridges can be rebuilt to greater height as was the case with the Bayonne Bridge on approach to the Port of New Orleans, bridge rebuilding is sometimes not a viable option for mainly cost reasons. The combination of redesigning or reconfiguring a ship and modifying its route operations and schedule offers a possible solution at several ports internationally. The X-bow allows for a low-elevation bridge located above and slightly behind the bow, with containers stacked to well above the height of the bridge.
A ship built to such configuration could sail through severe wave conditions across the North Atlantic to a transshipment terminal such as Quebec City or Halifax, where the upper levels of containers would be removed for transshipment. The ship would rise in the water to shallower sailing draft and telescopic air intakes retracted to allow the vessel to sail under the Bayonne Bridge into Port of Newark, under the Arthur Ravenel Bridge at Port of Charleston, under the Dames Point Bridge at Port of Jacksonville (JaxPort) and under bridges located between Ports of Montreal and Quebec City.
Traditional ship bows built with the conventional bow configuration tend to pitch when sailing into waves. Comparison sailing in identical severe wave conditions involving a ship built with a conventional bow and the other with the X-bow revealed that the X-bow responds with less slamming while the deflector built high above the bow redirects water spray away from a forward bridge. A vessel built with the combination of X-stern and X-bow offers reduced pitching when sailing at near steady cruising speed through severe wave conditions, in turn potentially reducing wave induced structural stresses along the vessel hull.
Stress induced by vessel pitching motions when sailing through severe wave conditions is one of the factors that restricts ship length. Depending on the amount by which the combination of X-bow and X-stern reduces pitching induced structural stresses, there may be scope to slightly extend vessel length and slightly increase the number of containers that it could carry. Further research would be required to determine possible lengthening of future container ships built with the combination of X-bow and X-tern, compared to vessels built with conventional bow and stern.
The maximum size of ship allowed to sail to Port of Montreal would measure 44-m beam by 294-m length. By comparison, the older generation Panamax ships that sailed to Montreal were built to 32-m beam. A container ship of 44-m beam by 294-m length and 10-m draft at part load may be built with combination X-bow and low level forward bridge, with upward extending telescopic air intakes at the stern area. When sailing on the ocean, it would sail at greater draft with containers stacked higher than the bridge, to be partially offloaded at Quebec City container terminal.
After being partially unloaded, sailing draft would decrease to 10-m with top level of bridge at same height as earlier generation Panamax ships. Air intakes would be retracted so as to allow vessel to sail to Montreal, carrying 17-container widths across its hull compared to 12-container widths of the earlier ship. A ship of such configuration could carry an additional 40 percent more containers to Port of Montreal compared to earlier Panamax ships.
The future navigation dimensions along Suez Canal parallel channels would likely allow for 1-TEU additional sailing draft, up to 3-TEU additional widths, 2-TEU additional height above water with forward bridge and 4-TEU additional length. The air draft restriction imposed by the bridge across the Suez Canal enhances future prospects for future mega-size container ships built with a low-level forward bridge, enhancing prospects to consider X-bow. The need to maximize container carrying capacity aboard future container ships enhances prospects to research whether combining X-bow with X-stern would sufficiently reduce pitch motion induced structural stresses to allow for ship lengthening.
Future trade between Asia and North America is likely to recover and increase, with larger container ships sailing via the Suez Canal and Western Mediterranean transshipments ports to North American east coast ports. The future operational success of container transfer technology at Halifax transshipment extended terminal would be essential for supersize container ships built with low-level forward control bridge to partially offload containers prior to sailing to Port of Newark. Interline ships would then carry the containers from Halifax to Boston, Portland, also Philadelphia and Baltimore via Delaware Bay along with ports located along the St. Lawrence Seaway.
Short Sea Ship
Shipbuilder Ulstein of Norway has undertaken research into developing a short-sea X-bow container ship of under 10,000-TEU capacity. However, they have not yet undertaken any research into larger X-bow container ships. The forward placement of the bridge of the short-sea X-bow concept container ship allows for partial offloading of containers from the upper levels at one port, to allow the partially loaded vessel to sail through shallower water and under bridges to a second port, as would be the situation along the Lower St. Lawrence River between Montreal and Quebec City.
The short-sea X-bow container ship with its low-level forward bridge provides the basis by which to develop a future version of 7,000 to 9,000-TEU capable of sailing the trans-North Atlantic service between European transshipment terminals and container terminals located along the Lower St. Lawrence River. Successful development of a trans-North Atlantic version of the short-sea X-bow container ship would subsequently provide the basis by which to develop larger versions of the ship.
The premium route for an X-bow container ship with forward control bridge carrying under 10,000-TEU would be the future Europe – Montreal service and involve partial ship offloading at Port of Laurentia. Future supersize container ships built with forward bridge roof built below the top level of containers would sail along a future twin-channel, deeper-draft Suez Canal while carrying 28,000 to 34,000-TEU. The layout with forward low-level bridge makes the X-bow an option for future container ships that will sail via an enlarged Suez Canal. Future research would determine the suitability for the X-bow to supersize container ships.
Go to Source
A massive fire broke out at the Port of Beirut on Thursday, incinerating a warehouse full of tires and oil within the port’s free zone. The same area was heavily damaged in the ammonium nitrate explosion that leveled the central port area and the adjacent waterfront on August 4. According to Lebanon’s civil defense agency, […]
Over the course of the past five days, the Australian Maritime Safety Authority arranged a medical intervention for an injured aboard a freighter in the Indian Ocean. On Saturday evening, the Spliethoff tweendecker Dolfijngracht called for assistance while under way about 1,000 nauical miles off the coast of Western Australia. A crewmember had sustained serious […]
The naval forces of the US and Bahrain recently staged a joint force training exercise which showcased the interoperability between coalition warships operating I the Arabian Gulf. Coalition Task Force Sentinel executed combined exercise Sentinel Shield supporting Sentry and Sentinel patrols in the coalition’s area of operations. The guided-missile destroyer USS John Paul Jones and […]
With close to 100 daily cargo flights operated to a destination network spanning more than 65 cities across six continents, Emirates SkyCargo is delivering essential supplies and commodities to people around the world. The air cargo carrier is currently operating 11 Boeing 777 freighter aircraft, each with a capacity to transport about 100 tonnes of […]
The National Transportation Safety Board (NTSB) has released a Marine Accident Brief about an accident that occurred on April 15, 2019, involving the towing vessel DeJeanne Maria which struck the end of a submerged dredge pipeline while pushing two spud barges to the Gulf of Mexico. The incident occurred on the Mississippi River in Pass […]
Best known as a leading passenger airport serving Germany’s most populated federal state North Rhine-Westphalia, Düsseldorf has become transformed into a vital distribution point, during the COVID 19 pandemic, for medical equipment and other life-saving goods, mostly from China. Gerton Hulsman, managing director of cargo operations, reports that the handling teams are working hard to […]
DSV Belgium has solid experience in the transport of pharmaceutical products for different customers. With a pharma hub based at Brussels Airport a lot of experience and know-how has been built up over the years. Last weekend, the forwarder handled one hundred million mouth masks, an important milestone for its Belgian organisation that has put […]
The UK government’s new post-Brexit tariff regime will result in both winners and losers. The new regime is set to replace the European Union’s Common External Tariff from the end of the Brexit Transition Period on December 31, 2020. The UK’s commitment to the ongoing Brexit process and ending the UK’s transition from EU membership […]
Emirates SkyCargo has expanded its weekly scheduled cargo flight operations to cover 75 destinations across six continents. Through its wider reach, Emirates SkyCargo is able to transport essential commodities and other urgently needed cargo more rapidly across the world, allowing exporters and importers across markets to benefit from direct access to widebody cargo capacity. Some […]
Global commercial aviation charter company Albion Aviation Group is reporting that it is seeing a considerable uptake in its professional cargo broker training courses from the current global pandemic crisis and surge in charter demand. “We have completed a number webinar courses for a whole of host of companies, looking to manage their own cargo […]
Operators can continue to use pilots and other crew members who have unable to comply with certain training, recent experience, testing, and checking requirements due to the COVID-19 outbreak in support of essential operations. Additionally, this Special Federal Aviation Regulation (SFAR) provides regulatory relief to certain persons and pilot schools unable to meet duration and […]
Astral Aviation has increased its intra-African network with cargo freighters during the pandemic. While there has been a reduction in capacity to, from, and within Africa, which has been caused by a stoppage of passenger flights and limited frequencies on freighter aircraft, Astral Aviation continues to operate cargo freighters from its Nairobi hub to 13 destinations […]
The U-Freight Group (UFL), with its considerable involvement in eCommerce logistics, says that the latest statistics showing that global e-commerce sales hit $25.6 trillion in 2018 are a further vindication of its decision to enter this sector of the international freight market several years ago. The latest available estimates, up 8% from 2017, were recently […]
Callan Marine is serving as the prime contractor to the Texas Department of Transportation for a maintenance dredging project located at the Bolivar Ferry Terminal, in Galveston, Texas. Work began in May and is estimated to be complete in late July 2020. The project consists of the removal of 600,000 cubic yards of material and […]
Network Airline Management and TAAG Angola Airlines are pleased to announce the renewal of their long-term freighter aircraft contract by an additional 12 months, sealing an ongoing partnership for the foreseeable future. Operating a regular weekly scheduled service from Liege, Belgium, to the capital of Angola, Luanda, Network Airline Management provides a Boeing 747-400F aircraft […]
Qatar Airways Cargo transported 56 SkyCell containers with vaccines from one of the largest vaccine manufacturers worldwide on its scheduled freighter and belly-hold cargo flights for its customer, CEVA Logistics. The 54-tonne shipment consisting of pneumococcal and varicella vaccines were flown from Brussels to Mumbai via the carrier’s hub in Doha on two separate flights. […]